Product ID:200, ZAP-IT
MSDS Date:10/01/1989
FSC:8010
NIIN:00N028110
MSDS Number: BPZBR

Emergency Phone: 213-686-1246

Info Phone: 213-686-1246

Cage: 52100

Telephone: 800-272-4687/818-442-7269

Cage: 52100

1.1%

CAS: 64742-88-7

Fraction By Weight: 47%

OSHA PEL 500 PPM (MFR)

ACGIH TLV: 500 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: HEADACHE, NAUSEA, DIZZINESS,
LASSITUDE, LOSS OF COORDINATION OR UNCONSCIOUSNESS. CHRONIC: NONE
RECOGNIZED.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: REMOVE TO FRESH AIR. GIVE ARTF RESP IF BRTHG HAS
STOPPED. EYES: FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15
MIN. SKIN: WASH WITH SOAP AND WATER. CHANGE CLOTHES & SHOES.
INGEST: DO NOT I NDUCE VOMIT. ASPIRATION OF VOMITUS MAY RESULT IN
CHEMICAL PNEUMONITIS &/OR PULMONARY EDEMA, CALL PHYS.

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:SEE ING 1
Extinguishing Media:USE FOAM, DRY CHEMICAL OR CO*2.
Fire Fighting Procedures:NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP. H*2O
MAY BE UNSUITABLE AS AN EXTING MEDIUM, BUT HELPFUL IN COOLING CONTR
& SURF. NEVER USE DIRECT (SUPP DATA)
Unusual Fire/Explosion Hazard:VAP ARE HVR/AIR & MAY ACCUMULATE IN LOW
AREAS OF POOR VENT. VAP CAN TRAVEL ALONG GROUND TO REMOTE IGNIT
SITES. CLSD CONTR CAN BUILDUP PRESS WHEN EXPOS TO HEAT.

Spill Release Procedures:REMOVE SOURCES OF IGNITION, INCLUDING HOT
METAL SURFACES. CLEAN UP SPILL IMMED BY SOAKING UP WITH ABSORBANT
SUCH AS CLAY, SAND, DIATOMACEOUS EARTH, ETC.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP COOL, DRY, AND AWAY FROM IGNITION
SOURCES. STORE IN WELL VENTILATED AREA.
Other Precautions:AVOID PERSONAL CONTACT (SKIN, EYES, ETC). USE WITH
ADEQUATE VENTILATION. DO NOT INHALE VAPORS. GROUND DRUMS WHEN
POURING OR OTHERWISE DISPENSING. DO NOT WELD, DRILL, CUT OR HEAT
FULL, PARTIAL, OR EVE N EMPTY CONTAINERS.

Respiratory Protection:IF TLV IS EXCEEDED, USE NIOSH/MSHA APPROVED
RESPIRATOR OR SCBA. USE MECHANICAL FILTER TO REMOVE SOLID AIRBORNE
PARTICLES DURING SPRAY APPLICATION.
Ventilation:GEN MECH VENT MAY BE SUFFICIENT TO KEEP EXPOS BELOW TLV.
USE ONLY EXPLO PROOF VENT W/FLAMMABLE MATERIALS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEM WORK GOG & FULL LNGTH FSHLD.
Other Protective Equipment:APRONS, EYE WASHES, SAFETY SHOWERS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC: STREAM OF WATER. USE WATER FOG AND AVOID SPREADING
BURNING LIQUID WHICH MAY FLOAT AND EVEN BURN ON TOP OF WATER
SURFACES.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:68

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:CO, CO*2, UNIDENTIFIED ORGANIC
COMPOUNDS.
Conditions to Avoid Polymerization:HEAT, SPARKS, OPEN FLAME.

Waste Disposal Methods:PLACE IN NON-LEAKING CONTAINERS AND DISPOSE OF
IN ACCORDANCE WITH APPLICABLE LOCAL, COUNTY, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.